The plaster crack repair for our ORC for November is coming along a little slowly. I wanted to have more done by this time of the month, but life happens. Confession: I have a bad habit of thinking that I have more time than I actually do. I am good about not overestimating time when it counts. We arrive at places and appointments on time, and if I have a deadline imposed by someone else, I will make it. However, when I am the only one truly affected by a situation, I do not always pull it together. That is part of what this ORC is about though. A deadline is set. The blog holds me accountable, and the work gets done…mostly.
Phase II
- Remove the drywall screws with plastic caps.
- Fill all of the holes with patch.
- Sand.
- Repeat patching and sanding until all of the holes are filled, and they become indistinguishable from the original plaster.
***
On Saturday, Andy removed the screws from the first phase of our plaster crack repair, because I never had the opportunity to remove them during the week as I had hoped. As expected, some of the cracks looked far worse after all of the drilling and adhesive.
I labeled the holes in photo below to identify the purpose of each type:
The next step was to run the edge of the scraper lightly and quickly over each crack in order to dislodge any bumps of glue or remaining wallpaper or imperfections.
After scraping, we vacuumed each crack thoroughly, and I used a flat screwdriver to gently dislodge any pieces of plaster that were loose, but stuck. The end result was a debris-free crack that patch would adhere to properly.
I do need to mention that I am slightly concerned about our adhesive. As I was scraping, I noticed that the adhesive seemed to have shrunk as it dried. That was not the case in every hole, but there were many in which the adhesive was suspect. This is the same adhesive that we used in O’s room, so I have no reason to believe that it is an issue of choosing the wrong product, but I suppose it could be brand inconsistency. The drying conditions were slightly colder this time, but they were within the acceptable range based on the product label. At this stage, we were forced to make a decision about how to proceed. We chose to move forward rather than redo the adhesive, knowing that more repairs may be in our future. This may be a giant regret later, but such is DIY life.
We are patching this room differently than we patched O’s room. In O’s room, I carefully spread the patch to fill each hole. I used several layers, and I spent hours feathering out the edges to make the cracks blend in with the existing walls. The end result was great, but the room took nearly two months to finish.
With this first layer of patch, unless the gaps or holes were very large, I just slapped the patch on, and ran my putty knife down the wall like a knife, scraping off everything except the patch that stayed in the holes. Since the walls are in such a general state of disrepair, after sanding, we will be skim-coating the entire surface of the walls with a layer of mud. This step could go just right or very wrong since we do not have experience with this skill. Cross your fingers…
It took about six hours to finish the patching. I was able to listen to every Serial podcast, and holy cow, I am hooked! Anyone else out there glued to this fascinating podcast about the 1999 murder of a Baltimore high school girl? Did they convict the right killer? That question is rhetorical at this point. Oh forget rhetorical, what do you think? Did he do it? That question takes up way too much of my brain’s real estate right now. When you get a chance, listen to the podcast, and then read this article. I think you will be hooked too.
By the end of Saturday’s wall patching, binge-listening session, it was dark outside and the room looked a bit garish and not at all inviting as a boy’s bedroom. In fact, there is a bit of a haunted house quality to the room right now. We have a mess on our hands, but we know it always looks worse before it looks better.
That is where our project ended for the weekend. Sunday, we had other obligations, and no work was done on the room. I typically do not share too much about our kids on this blog, but I am going to end today with a couple of cute pictures of M. at her gymnastics clinic. That is where my Sunday afternoon went, and it was worth every minute. Her first meet is in just a few weeks, and she is so excited. (Sorry for the slightly blurry photos.)
Today, we are settling in for piles of snow. There is a couple of inches on the ground already, and there is no end in sight. It is the perfect day for hot chocolate and lots of snuggling, and we will fit some wall patching in there somewhere.
